Product ID:HEATING FUEL NO. 1
MSDS Date:01/03/1992
FSC:9140
NIIN:00-286-5286
MSDS Number: BPFBG

CHEVRON ENVIRONMENTAL HEALTH CENTER INC.

15299 SAN PABLO AVE.
RICHMOND, CA 94804
US

Emergency Phone: 800-457-2022/415-233-3737

Info Phone: 415-233-3737

Cage: 0AHD1

CHEVRON ENVIRONMENTAL HEALTH CENTER INC

4054 RICHMOND, CA 94804 US

Telephone: 800-582-3835

Cage: 0AHD1

ALIPHATIC PETROLEUM SOLVENT

CAS: 8008-20-6

RTECS: OA5500000

Fraction By Weight: <100%

OSHA PEL 400 PPM PETR. DIST.

ACGIH TLV: 400 PPM RUBBER SOLV.

KEROSENE, HYDRODESULFURIZED

CAS: 64742-81-0

Fraction By Weight: <100%

OSHA PEL 400 PPM PETR. DIST.

ACGIH TLV: 400 PPM RUBBER SOLV.

DISTILLATES, HYDRODESULFURIZED MIDDLE

CAS: 64742-80-9

Fraction By Weight: <100%

OSHA PEL 400 PPM PETR. DIST.

ACGIH TLV: 400 PPM RUBBER SOLV.

DISTILLATES, STRAIGHT RUN MIDDLE

CAS: 64741-44-2

RTECS: LX3296000

Fraction By Weight: <100%

OSHA PEL 400 PPM PETR. DIST.

ACGIH TLV: 400 PPM RUBBER SOLV.

LD50 LC50 Mixture:LD50 (ORAL RAT) IS > 5 ML/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: IRRITATION OF ALL BODY TISSUES.
ASPIRATION INTO LUNGS CAN LEAD TO CHEMICAL PNEUMONIA. CHRONIC:
DERMATITIS. RISK OF SKIN CANCER.
Explanation of Carcinogenicity:SOME MIDDLE DISTILLATES CAUSE SKIN
CANCER WHEN REPEATEDLY APPLIED TO MICE OVER THEIR LIFETIME.
Effects of Overexposure:EYES: MILD IRRITATION. SKIN: IRRITATION,
DERMATITIS. INHALATION: NOSE, THROAT AND LUNG IRRITATION, HEADACHE,
DIZZINESS, CENTRAL NERVOUS SYSTEM DEPRESSION. INGESTION: MOUTH,
THROAT AND STOMACH IRRITATI ON, NAUSEA, VOMITING, DIARRHEA AND
RESTLESSNESS. ASPIRATION INTO LUNGS WILL CAUSE CHEMICAL PNEUMONIA.
Medical Cond Aggravated by Exposure:PERSONS WITH A HISTORY OF SKIN,
RESPIRATORY OR CENTRAL NERVOUS SYSTEM DISORDERS MAY BE AT INCREASED
RISK FROM EXPOSURE.

First Aid:EYE: IMMEDIATELY FLUSH WITH PLENTY OF WATER FOR 15 MINUTES.
GET MEDICAL ATTENTION. SKIN: REMOVE CONTAMINATED CLOTHING. WASH
WITH SOAP AND WATER. INHALATION: REMOVE TO FRESH AIR. GIVE
OXYGEN/CPR IF NEE DED. SEE DOCTOR IF BREATHING DIFFICULTIES
CONTINUE. INGESTION: GIVE WATER OR MILK. DO NOT INDUCE VOMITING.
GET MEDICAL ATTENTION.

Flash Point Method:TCC
Flash Point:100F,38C
Lower Limits:0.6
Upper Limits:4.7
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED
CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:MODERATELY COMBUSTIBLE. CAN BURN IN THE
OPEN OR BE EXPLOSIVE IN CONFINED SPACES. COMBUSTION OR HEAT OF FIRE
MAY PRODUCE HAZARDOUS DECOMPOSITION PRODUCTS/VAPORS.

Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT, ELIMINATE SOURCES
OF IGNITION, AND VENTILATE AREA AS REQUIRED. ABSORB WITH INERT
MATERIAL. PLACE WASTE IN DOT APPROVED CONTAINER FOR DISPOSAL. SPILL
AREA MAY BE SLIPPERY. WA SH WITH SOAP AND WATER.

Handling and Storage Precautions:STORE IN A COOL, DRY, WELL VENTILATED
AREA AWAY FROM HEAT AND IGNITION SOURCES. KEEP CONTAINER CLOSED
WHEN NOT IN USE. DO NOT USE AS CLEANING AGENT.
Other Precautions:EMPTY CONTAINERS RETAIN RESIDUE. OBSERVE HAZARD
PRECAUTIONS WHEN HANDLING EMPTY CONTAINERS. SPECIAL SLOW LOAD
PROCEDURES FOR "SWITCH LOADING" MUST BE FOLLOWED WHEN THIS MATERIAL
IS LOADED INTO TANKS P REVIOUSLY CONTAINING GASOLINE.

Respiratory Protection:NONE NORMALLY NEEDED. IF VENTILATION DOES NOT
MAINTAIN INHALATION EXPOSURES BELOW PEL (TLV), USE NIOSH/MSHA
APPROVED RESPIRATOR AS PER CURRENT 29 CFR 1910.134,
INSTRUCTIONS/WARNINGS AND NIOSH-RESPIRAT OR SELECTION.
Ventilation:MECHANICAL (GENERAL) VENTILATION IS USUALLY ADEQUATE.
Protective Gloves:PVC, RUBBER GLOVES
Eye Protection:SAFETY GLASSES/CHEMICAL SPLASH GOGGLES
Other Protective Equipment:SAFETY SHOWER AND EYE BATH. INDUSTRIAL TYPE
WORK CLOTHING AND APRON AS REQUIRED TO AVOID PROLONGED OR REPEATED
CONTACT.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING AND BEFORE
EATING OR DRINKING. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
USE OF THIS HEATING OIL IN NON-FLUE CONNECTED HEATING APPLIANCES CAN
RESULT IN PERSONAL INJURY. MATERIALS SIMILAR OT SOME COMPONENTS IN
THIS PRODUCT WERE FOUND TO BE MUTAGENIC IN VITRO AND IN VIVO TES
TS. RELATIONSHIP TO HUMAN EFFECTS IS NOT KNOWN.

HCC:F4
Boiling Pt:B.P. Text:400F,204C
Vapor Pres:<5
Vapor Density:5-11
Spec Gravity:0.85
Viscosity:1.9 CST @104F
Evaporation Rate & Reference:<1 (ETHER = 1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:LIGHT YELLOW TO AMBER-COLORED LIQUID. KEROSENE
ODOR.
Percent Volatiles by Volume:10-30

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS SUCH AS CHLORINE AND OXYGEN, STRONG ACIDS AND
ALKALIES.
Stability Condition to Avoid:HIGH HEAT, OPEN FLAMES AND OTHER SOURCES
OF IGNITION
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE,
SULFUR OXIDES, OTHER INCOMPLETELY BURNED CARBON PRODUCTS.

Waste Disposal Methods:CONSULT YOUR LOCAL ENVIRONMENTAL OFFICER.
DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE FEDERAL, STATE AND
LOCAL REGULATIONS. MANUFACTURER SUGGESTS LAND DISPOSAL OR
INCINERATION. EPA IGNITABLE HAZARDOU S WASTE D001.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.